Lotus Service Notes Section OK - VSI - Lotus Cars


Mar 25, 2013 - ...

3 downloads 230 Views 389KB Size



Lotus Service Notes

Section OK

MAINTENANCE & LUBRICATION

SECTION OK



Page

Fluid Change Intervals

2

Severe Service Conditions Maintenance Schedule Pre-Delivery Inspection

2



Pre-Delivery Paint Mark Up

8



Licence Plate Fitment

9

3 6

Page 1

Upda ted 25th March 2013





Lotus Service Notes

Section OK

fluid change intervals Please see service notes section TDU for information on fluid capacities, standards and approved products. Engine In order to ensure the longevity and reliability of the vehicle, it is most important that only the specified lubricants are used. It is an entirely false economy to try to save money by using lower quality oils, which may break down before the next change interval and provide inadequate protection before the end of the term. High oil consumption may also result. Throughout the life of the vehicle (including topping up during the running-in period if required) a fully synthetic 5W/30 or 5W/40 oil should be used. A top quality fully synthetic 5W/40 oil, such as ‘Petronas Syntium Racer X1 5w40' is suitable for all climatic conditions and engine speeds likely to be encountered*. Note that no oil additives are approved by Lotus. Engine Oil change interval Refer to Maintenance Schedule Transmission - Manual Non Supercharged (gearbox & final drive) Oil change interval Refer to Maintenance Schedule Transmission - Manual Supercharged (gearbox & final drive) Oil change interval Refer to Maintenance Schedule Transmission - IPS (gearbox, torque converter & oil lines) Oil change interval Refer to Maintenance Schedule Brake & Clutch System Fluid change interval

24 months

Power Steering System (PAS) Fluid change interval:

Not routine

Engine Coolant Additive Coolant change interval

4 years

* If the vehicle is to be driven hard in very high ambient temperatures, or used on a race track, the recommended fully synthetic engine oil is Petronas Syntium 7000 0W/40. 'Severe Service’ Conditions Certain operating conditions can cause rapid degradation of the oil quality, either by the accumulation of dirt particles, or by the absorption of water from condensation. If any of the ‘severe service’ conditions described below apply, it is recommended that the oil and filter be changed twice as frequently as is listed in the Maintenance Schedule. • • •

Driving in dusty areas (e.g. on unmetalled roads); Change the oil and filter as soon as possible after driving in a dust storm. Stop/start driving with frequent short trips where the engine rarely warms up thoroughly (especially in cold weather/climates); and/or frequent or prolonged idling. Track use, with repeated high rpm, wide throttle openings and high oil temperatures. In these circumstances, individual judgement must be made regarding appropriate servicing. Note that use of the car off road or in a competitive manner, including timed runs or laps, will invalidate warranty and require appropriate levels of expert car preparation and servicing.

Page 2

Upda ted 25th March 2013



Lotus Service Notes

Section OK

MAINTENANCE SCHEDULE - EVORA LSL537e

Job no.: ........................ Owner's name: .....…………....................... Vehicle: ..............………...……….. Vehicle registration no.: ......………................... V.I.N.: ......………................................................… Recorded mileage: ........………...…….………… Mileage at last service.: ..............……………… Today's date: ………………..………...…………… Date of last service: ……………………… EXPLANATORY NOTES: Required Maintenance In order to maintain warranty validation and help ensure proper safety, emissions performance and dependability of the vehicle, Lotus Cars Ltd. requires that the vehicle be serviced in accordance with this schedule. Under normal usage conditions, a routine maintenance service should be perfromed at the first occurring of 9,000 miles (15,000 km) or 12 months from the previous service. The approved service period extends to 500 miles (800 km) before/after or one monthbefore/after the stipulated distance/time. Any necessary repairs should be completed without delay. A cross ( X ) in the following table indicates an operation to be performed. The corresponding box should be ticked when the operation has been satisfactorily performed, or the X circled if extra work and time is required. The approval of the customer should be obtained before any extra work is undertaken, details of which should be recorded in the space provided at the end of the schedule.

Inspect' means assess condition and test for correct operation. Extra time is required to adjust or repair - advise customer beforehand if necessary. Check' means test and adjust/fill or tighten as necessary. Labour time is included. Special Operating Conditions If the car is subjected to one of the following 'special operating conditions', additional servicing is required: - Regular use on unpaved or dusty roads (1,2) - Use in mountainous areas with severe or prolonged brake usage (3) - Frequent short trips with cold engine (esp. in cold weather/climates); and/or frequent or prolonged idling (1) - Occasional circuit use, with repeated high rpm, wide throttle openings and high oil temperatures (1,3,4) - Competition, or timed track use (5)

Additional servicing: 1. Oil & filter change @ 4,500 m (7,500 km) intervals. 2. Transmission oil change 4,500m (7,500km)/6 mth intervals 3. Inspect air cleaner @ 9,000 m (15,000 km) intervals, or as required. 4. Inspect brake pads & discs @ 4,500m (7,500 km) intervals, or as required. 5. Thorough safety check including wheels, tyres, suspension, steering and brake systems. 6. The Lotus Evora is designed as road going sports car. It is recognised that owners may wish to use the car occassionally on closed circuit tracks to experience the car's full range of dynamic capabilities. However, use of the car in a competitive manner, including timed runs or laps, is not endorsed by Lotus. This type of timed, competitive use will invalidate warranty and require appropriate levels of expert vehicle preparation and servicing.

After Sales Service To be performed within 1,000 - 1,500 miles (1,500 - 2,500 km) or 12 months of vehicle sale, whichever first occurs. Dependant upon the market , if carried out by the selling dealer, there is no charge to the vehicle owner for the labour content of the After Sales Service. Only for materials used will a charge be made. Check with your dealer to confirm if your vehicle is valid for this offer . To maintain warranty validation, an Engine History Report print out from the Lotus TechCentre must be submitted to the Warranty Department.

Recommended Lubricants & Fluids Lotus recommends the use of PETRONAS products for many of its vehicle models. Please refer to the relevant 'Vehicle Data' sections of the workshop service notes for a full list of capacities, standards and approved products.

Page 3

Upda ted 25th March 2013



Op. No. 1 2 2a 3 4 4a 5 5a 6 6a 7 9 10 11 12 13 14 15 16 17 17a 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Lotus Service Notes

Operation description Fit protective covers to seats, footwells, steering wheel and rear body Lubrication Renew engine oil and filter - normal conditions Renew engine oil and filter - special conditions Inspect engine & transmission for oil leaks Renew manual or IPS transmission oil - normal conditions Renew manual or IPS transmission oil - special conditions Engine Inspect air cleaner element - normal conditions Inspect air cleaner element - dusty conditions Renew air cleaner element - normal conditions Renew air cleaner element - dusty conditions Renew spark plugs Inspect auxiliary drive belt condition Inspect integrity of fuel system Inspect for fault codes & ECU programme level Print Engine History & Performance reports and return to Lotus Cooling System Inspect water radiator & pipework for damage or leaks. Clean radiator finning Check coolant level Renew coolant Braking System Inspect parking brake adjustment Inspect brake pad thickness & disc condition - normal cndts. Inspect brake pad thickness & disc condition - special cndts. Inspect brake hoses, pipes & hydraulic units Check brake fluid level Renew brake/clutch fluid Steering & Suspension Check security and condition of front & rear suspension Inspect dampers for leaks and performance Inspect front and rear wheel bearings for play Inspect condition of drive shaft gaiters Inspect steering ball joints and gaiters Inspect free play at steering wheel Wheels & Tyres Inspect tyre condition & set pressures Electrical Check battery & terminals for security & condition Inspect operation of all lights Body Inspect operation & adjustment of hinges and latches, manual door locks Inspect operation & condition of seat belts Inspect wiper operation & top up windscreen washer reservoir Renew pollen filter Renew alarm transmitter batteries (check with customer)

Section OK

After Sales X

Service Type 9,000m Other (15,000km) Intervals or 12 months X

X 4,500m (7,500km)/6 mth X X 36,000m (60,000km)/4 yr 4,500m (7,500km)/6 mth X

X As required 36,000m (60,000km)/4 yr As required 54,000m (90,000km) X X X X X X X

X

4yrs

X X 4,500m (7,500km) X X X 18,000m (30,000km)/2 yr X

X X X X X X X

X

X X

X X

X

X

X

X X 18,000m (30,000km)/2 yr 1 yr

Page 4



Lotus Service Notes

Section OK

Road Test Performance Engine performance ...........................…..................

Tailpipe CO ...........................................................

Clutch operation ......................................................

Gearbox operation ................................................

Brake performance ...................................................

Steering performance ...........................................

Driveline & suspension noise/vibration .......................

Wheel balance ......................................................

General comments …………………………………………………………………………………………………… ...........................................................................................................………………………............. …………………………………………………………………………………………………………………………..

Additional Work Performed or Required ………………………………………………………………………………………………………………………….. ………………………………………………………………………………………………………………………….. ………………………………………………………………………………………………………………………… ………………………………………………………………………………………………………………………......

Work completed by ............................................… Owner's Maintenance Booklet stamped: …………

Recommended Service Times After Sales Service: Regular Service: Op. 2a: Op.4 Manual Transmission: Op.4 IPS Transmission: Op.5a: Op.6a: Op.7: Op.15: Op.17a: Op.20: Op.33: Op.34:

1.9 hr 2.8 hr 0.6 hr 0.4 hr 1.0 hr 0.1 hr 0.7 hr 0.6 hr 1.0 hr 0.1 hr 0.6 hr 0.1 hr 0.1 hr

Dealer Stamp:

Date:

Page 5

Lotus Service Notes



Section OK

++++++++++++,% +   +.+ +  + +++++++++++++++++++++++++++++++++++++++++++222222222222222222222222222222222222222222222<=> '(22 2 2.((2 '2:2  2,(('2 2  ,( 2 2 2(2 22 ,6

 222A2A2'2 222A2A2A2*, !



%

 2A2A2A2A2A2A2A2A2A2A2A2A2A2A



 +  2  #2 #2 2(32 &''2:22&'6 +$ $232(, 2:22 '2'#'6 $2 '(2''2'#'6 $+ " 22:2(, 2 2 '2'($6 " 2 '2,2 2'($6 222''2'2($2( 2 22'2,2 2'($6 %2 2! 2 2$2 2  2 6 )#+/+ $2 ' 22 62 $2 2 2&'2- '6 $2&' 2(22 22(2'(2 , (,6 #$# $22 2-(2,('2( 2# '(62' &29;6=)2(62' &2996?)2 '(16 " 2 ( 2 2('(,2,32 2:2'2'( 2'(6 " 2 ( 2 2(''2+ 2:2 2'(, 6 " 2 ( 2 2 2:2(( 2&6 " 2& 2 ( 2(2(''2  2:2 ($2  6 " 22&(2:2 &&(2 ( 32 2(',2:2 2 2# 2'#'6 " 2 ( 2 2(''2,32, 2( ,2:2 ' 6 " 2 ( 2 2(272(2   2:2-' &2(6 " 2 ( 2 2(  2 ,2:22,2' $2/2(

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

Page 6

Upda ted 25th March 2013



Lotus Service Notes

Section OK

Road Test Performance Check - Add comments as necessary Engine performance: Foot & parking brake performance: Clutch operation: Gearbox operation: Steering performance: Check wheel balance: Driveline/suspension noise/vibration: General Comments

Additional Work Required

Additional Work Completed by: Valet Undertake complete vehicle valet. Notes - The PDI is subject to the following conditions:

Dealer stamp:

a) It is the responsibility of the supplying dealer to ensure that the car is delivered to the customer in the best possible condition. b) All costs incurred during the inspection process are the responsibility of the dealer. c) Failure to return a signed copy of this inspection to Lotus Cars Ltd. by the dealer, may result in warranty claims on the particular car being rejected.

Pre-Delivery Inspection Completed by: Date:

ONCE COMPLETED, SEND OR EMAIL A COPY OF THIS PDI FORM, A PAINT MARK UP SHEET, OWNER'S HANDBOOK MAINTENANCE RECORD "P.D.I AND NEW CAR HANDOVER CHECKLIST (LSL486) TO: WARRANTY DEPARTMENT, LOTUS CARS LTD. UNITS 6 & 7 JOHN HYRNE WAY LONGWATER BUSINESS PARK COSTESSEY NORWICH NORFOLK NR5 OAF ENGLAND OR EMAIL TO : [email protected]

Page 7



Lotus Service Notes

Section OK

PRE-DELIVERY PAINT MARK UP - EVORA

VIN COLOUR OWNER DATE OF PDI

lsl544

PAINT DEFECT CODE B C D F G H K M

BLISTERING CHIPS DISTORTION FLAKING GEL CRAZING PIN HOLES SINKAGE MAT CREASES

N O P R S T U V

SHADING OVERSPRAY PRE-RELEASES RUN SCRATCHES THIN PAINT DIRT UNDER PAINT VOIDS

Page 8



Lotus Service Notes

Section OK

Licence Plate Fitment Front The mounting plinth for the front licence plate is screw fixed to the front clamshell, and is slightly curved in plan. Typically, the plate is secured using double sided tape in conjunction with two fixing screws with suitable blind fix nuts (e.g. Rawlnuts). The plate should be aligned with the bottom edge of the plinth to reduce potential damage from grounding or kerbs, whilst providing the minimum restriction to radiator airflow. Rear

The rear licence plate should be mounted on the surface of the rear transom recess using double sided tape and/or fixing screws at the dealer's/customer's discretion. Ensure that any holes drilled through the body are suitably weather sealed.

Page 9